Just Dan's little resto on a 34L Tenere'

User avatar
Mezo
Dashingly Handsome
Dashingly Handsome
Posts: 6108
Joined: Wed Mar 23, 2011 11:01 am
What Bike or Bikes Do You Own?: Kymco agility 125 ;-)
Previously Owned Bikes: Honda SS50, Suzuki TS50, Honda CB100, Honda CR125RZ, Yamaha YZ125, Kawasaki KX250, Suzuki TL1000S, Ducati 900SS, Ducati 900SL, a few Tenere`s.
Location: Queensland Australia
Contact:

Just Dan's little resto on a 34L Tenere'

Post by Mezo »

Yep you can drop the engine forward, take off the rocker cover, release the cam chain tensioner & then tilt the cam out sideways.

I can go through it with you on Skype Dan, its not that big a deal trust me.

Mezo.
"A wise man makes his own decisions, an ignorant man follows public opinion"
GeoffD
Founding Member
Founding Member
Posts: 1700
Joined: Sun Mar 27, 2011 7:19 pm
What Bike or Bikes Do You Own?: 7 x 3AJ Teneres
1 x 1VJ Tenere
55W Tenere
XT660 Tenere 4MY
Honda CRF1000 Africa Twin
Honda Monkey Bike
Honda Dax
Previously Owned Bikes: Triumph Tiger Cub, Garelli Tiger Cross, Triumph Trophy 650, Honda CB250 G5, Honda CB750 K7, Yamaha DT175MX, Honda CB250 Super Dream, Yamaha RD350LC YPVS, Honda XR250, Yamaha XT600, Suzuki PE175, Yamaha YZ125, Yamaha RD500 V4, Yamaha XT600 Tenere (3AJ), Kawasaki ZX10, BMW R100GS PD, Honda XR600, Honda Varadero, Honda Africa Twin, Honda Transalp, Triumph Thunderbird, Ducati 900 Superlight FE, Ducati 750 SS, Honda Fireblade, Kawasaki Versys 650, Suzuki GT750 Kettle, Super Tenere
Location: Tenereland, North East England.

Re: Just Dan's little resto on a 34L Tenere'

Post by GeoffD »

Dan its normal for the engine to roll a bit, doesn't mean the timing's out... & besides you don't need to be exact with the 'T' mark to check your tappets... just make sure the cam lobes are pointing downwards......
Try again but this time remove the spark plug (the engine won't roll as much without the plug in too) put a pencil or something in the plug hole till you feel the top of the piston & turn the engine over till its at TDC....
The future is not what it used to be....
User avatar
Just Dan
Founding Member
Founding Member
Posts: 216
Joined: Tue Mar 29, 2011 7:30 am
Location: Hobart
Contact:

Re: Just Dan's little resto on a 34L Tenere'

Post by Just Dan »

GeoffD wrote:Dan its normal for the engine to roll a bit, doesn't mean the timing's out... & besides you don't need to be exact with the 'T' mark to check your tappets... just make sure the cam lobes are pointing downwards......
Try again but this time remove the spark plug (the engine won't roll as much without the plug in too) put a pencil or something in the plug hole till you feel the top of the piston & turn the engine over till its at TDC....
Hi Geoff, This is the process I am already using. Plug out and and using a scribe to gently rest on the piston to see where TDC is. It is looking like TDC is where the timing mark is resting in the photo. If I roll the engine back to the T mark. The piston is still coming up the bore.

Image
Bacon and eggs...A day's work for a chicken, a lifetime commitment for a pig.
User avatar
Just Dan
Founding Member
Founding Member
Posts: 216
Joined: Tue Mar 29, 2011 7:30 am
Location: Hobart
Contact:

Re: Just Dan's little resto on a 34L Tenere'

Post by Just Dan »

Oh well eat humble pie. :blush:

The timing is not out at all. Had a peek under the rocker cover to if the timing marks line up and the lobes are down.
Image
Bacon and eggs...A day's work for a chicken, a lifetime commitment for a pig.
User avatar
Mezo
Dashingly Handsome
Dashingly Handsome
Posts: 6108
Joined: Wed Mar 23, 2011 11:01 am
What Bike or Bikes Do You Own?: Kymco agility 125 ;-)
Previously Owned Bikes: Honda SS50, Suzuki TS50, Honda CB100, Honda CR125RZ, Yamaha YZ125, Kawasaki KX250, Suzuki TL1000S, Ducati 900SS, Ducati 900SL, a few Tenere`s.
Location: Queensland Australia
Contact:

Re: Just Dan's little resto on a 34L Tenere'

Post by Mezo »

I notice there is a bit of excess sealant there Dan, i have read a few horror stories about about them little worms making there way in to an oilway & blocking the passage of oil.

Before i fired up my bike i had said to Danny about my concerns & showed him where the tacho drive goes, i had put whey to much sealant on there and it was blocking oil comming in to the cam (it would have starved the cam dry) lucky Danny had said "Dont risk it lets take it off".

You only need the thinest smear of sealant, but pay attention to the end of the cam where the tacho drive goes.

Mezo.
"A wise man makes his own decisions, an ignorant man follows public opinion"
User avatar
Just Dan
Founding Member
Founding Member
Posts: 216
Joined: Tue Mar 29, 2011 7:30 am
Location: Hobart
Contact:

Re: Just Dan's little resto on a 34L Tenere'

Post by Just Dan »

Understand what you are saying. That is why we use Loctite 515 Master gasket. 515 only goes off on contact of 2 surfaces. Any excess dissolves into the oil preventing block oil ways.

just checking the valves. Both inlet valves were the tight side at .06mm
Bacon and eggs...A day's work for a chicken, a lifetime commitment for a pig.
User avatar
Mezo
Dashingly Handsome
Dashingly Handsome
Posts: 6108
Joined: Wed Mar 23, 2011 11:01 am
What Bike or Bikes Do You Own?: Kymco agility 125 ;-)
Previously Owned Bikes: Honda SS50, Suzuki TS50, Honda CB100, Honda CR125RZ, Yamaha YZ125, Kawasaki KX250, Suzuki TL1000S, Ducati 900SS, Ducati 900SL, a few Tenere`s.
Location: Queensland Australia
Contact:

Re: Just Dan's little resto on a 34L Tenere'

Post by Mezo »

Yep bit tight there Dan (but thats how we like it) whey hey. :bouncing-boobs:

Book says .7 to .12 cold so a little slack wouldnt hurt.

Mezo.
"A wise man makes his own decisions, an ignorant man follows public opinion"
User avatar
Dirtybrit
Financial
Financial
Posts: 443
Joined: Tue Mar 29, 2011 4:42 am
What Bike or Bikes Do You Own?: 1982 XT 550, 1981 YZ250, 2010 Triumph Tiger 1050, 1981 XR 200
Previously Owned Bikes: Honda SS50, Yamaha RD2501973, Honda XL125, Yamaha DT175, Kawasaki KE175, Yamaha YZ250D, CT90, Suzuki RM400, Yamaha YZ250H, 1981 Yamaha RD250,1982 XT 550, 1979 XS 750, 1979 YZ 400 F.
Location: Calgary Alberta Canada

Re: Just Dan's little resto on a 34L Tenere'

Post by Dirtybrit »

Just Dan wrote:Understand what you are saying. That is why we use Loctite 515 Master gasket. 515 only goes off on contact of 2 surfaces. Any excess dissolves into the oil preventing block oil ways.

just checking the valves. Both inlet valves were the tight side at .06mm
Thats probably it Dan!, the wear on my cam stopped my bike from starting at all! other guys on the forum that shall not be mentioned have told me that aswell, check your valves are in spec first! :rtfi:
55W1985
Almost there
Almost there
Posts: 781
Joined: Sun Apr 03, 2011 6:46 am
What Bike or Bikes Do You Own?: XR 650L 1994,XT 600Z 55W 1985
Previously Owned Bikes: CX 500 1981,R-80G/S PD 1987
Location: Buenos Aires,ARGENTINA
Contact:

Re: Just Dan's little resto on a 34L Tenere'

Post by 55W1985 »

Dan this is what are waiting for us!!!!!! :pleasesir: :congrats: :shades: :bouncing-boobs:
http://www.youtube.com/watch?v=oKsuwA9VeK0
XR650L(1994) 55W (1985)
User avatar
Just Dan
Founding Member
Founding Member
Posts: 216
Joined: Tue Mar 29, 2011 7:30 am
Location: Hobart
Contact:

Re: Just Dan's little resto on a 34L Tenere'

Post by Just Dan »

55W1985 wrote:Dan this is what are waiting for us!!!!!! :pleasesir: :congrats: :shades: :bouncing-boobs:
http://www.youtube.com/watch?v=oKsuwA9VeK0
Yes sir can I have one of those.....

While I had the rocker cover off yesterday. I heard a very faint "tink" . Had a good look a round with a head torch and mirror and could not see any thing in with the valves. After tightening the rocker cover back up. I notice the little aluminium screw on bit for the spark plug is missing. XR650 plug leads need the spark plug cap to clip on to that screw on bit. Looks like I will be pulling the rocker cover off again.

Rode the RS out to yammie dealer this morning to pick up and oil filter , o rings and that special bolt on the bottom of the oil fiter. Giving the RS a good handful of throttle exiting a roundabout cranking left. The rear wheel spun up big time just like a GP bike. :lol: Who would a thought a push rod twin would spin up.

Always some thing weird happening around my place. Looked out the lounge room window to see my next doors elderly dog Dilbert sitting on the roof.....
Image
Bacon and eggs...A day's work for a chicken, a lifetime commitment for a pig.
Post Reply